Product ID:TT-V-71H, FLOOR AND TRIM VARNISH
MSDS Date:04/19/1989
FSC:8010
NIIN:00-165-4420
MSDS Number: BJXHC

Emergency Phone: 201-333-6986

Info Phone: 201-333-6986

Cage: FO833

Telephone: 201-437-6501

Cage: 33150

MINERAL SPIRITS, EXEMPT

CAS: 64742-88-7

Fraction By Weight: 54%

OSHA PEL 500 PPM

ACGIH TLV: 125 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION:IN EXTREME
CASES,UNCONSCIOUSNESS AND DEATH MAY OCCUR.INGESTION:INGESTION OF
PRODUCT MAY RESULT IN VOMITING.ASPIRATION OF VOMITUS INTO THE LUNGS
MUST BE AVOIDED AS EVEN SMALL QUANTITIES MAY RESULT IN ASPIRATION
PNEUMONITIS WHICH MAY BE EVIDENCED BY COUGHING,LABORED BREATHING
AND CYANOSIS.IN SEVERE CASES:DEATH
Effects of Overexposure:EYES:HIGH CONCENTRATIONS MAY BE
IRRITATING.SKIN:SLIGHTLY IRRITATING.PROLONGED EXPO MAY CAUSE
DEFATTING/DRYING OF SKIN,LEADING TO
IRRITATION/DERMATITIS.INHALE:HIGH CONCENTRATIONS MAY BE IRRIT TO
NOSE,R ESPIRATORY TRACT AND MAY CAUSE CENTRAL NERVOUS SYSTEM
DEPRESSION,EVIDENCED BY GIDDINESS HEADACHE,DIZZINESS AND NAUSEA.
Medical Cond Aggravated by Exposure:PREXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:EYE:FLUSH W/WATER FOR 15 MIN WHILE HOLD EYELIDS OPEN.GEN MED
ATTN.SKIN:FLUSH W/WATER.REMOVE CONTAMINATED CLOTHES/SHOES.WASH
W/SOAP/WATER.DO NOT REUSE CLOTHES/SHOES UNTIL CLEANED.IF IRRIT
PERSISTS,GET MED ATTN.INHALE:REMOVE TO FRESH AIR/PROVIDE OXYGEN IF
BREATHING DIFFICULT.GIVE CPR IF NOT BREATHING.GET MED
AID.INGESTION:DO NOT INDUCE VOMIT.IF VOMIT OCCURS
SPONTANEOUSLY,KEEP HEAD BELOW HIPS.*

Flash Point Method:TCC
Flash Point:105F/41C
Lower Limits:1
Upper Limits:6
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:DO NOT ENTER SPACE W/OUT FULL BUNKER
GEAR,INCLUDE POSITIVE PRESS NIOSH APPROVE SCBA.COOL FIRE EXPOSE
CONTAINER W/H2O.DO NOT USE DIRECT STRM OF H2O ON POOL FIRES
Unusual Fire/Explosion Hazard:CONTAINER EXPOSED TO HIGH HEAT FROM FIRE
SHOULD BE COOLED W/WATER TO PREVENT VAPOR PRESS BUILD-UP.COOL
CONTAINER AREAS EXPOSED TO DIR FLAME W/LARGE QUANT WATER.

Spill Release Procedures:REMOVE SOURCES OF IGNIT.WEAR APPROPRIATE
RESPIRATOR/PROTECT CLOTH.SHUT OFF SOURCE IF
SAFE.DIKE/CONTAIN.REMOVE W/VACUUM TRUCKS/PUMP TO STORAGE/SALVAGE
VESSEL.SOAK UP W/ABSORBENT.PLACE IN NON-LEAK CONTA INER/SEALED
TIGHTLY FOR DISPOSE.FLUSH AREA W/WATER

Handling and Storage Precautions:THIS PRODUCT IS CLASSIFIED AS AN
OIL.SPILLS INTO SURFACE WATERS,AIR OR LAND MUST BE REPORTED TO THE
NATIONAL RESPONSE CENTER 1-800-424-8802.
Other Precautions:VAPORS MAY ACCUMULATE/TRAVEL TO IGNIT SOURCES DISTANT
FROM THE HANDLING SITE.KEEP CONTAINERS CLOSED WHEN NOT IN USE.DO
NOT CUT,DRILL,GRIND,WELD,ETC.ON/NEAR CONTAINERS.SURFACES THAT ARE
SUFFICIENTLY HO T MAY IGNIT PRODUCT IN ABSENCE OF SPARK.

Respiratory Protection:IF EXPOSURE DOES EXCEED OCCUPATIONAL EXPOSURE
LIMITS,USE A NIOSH APPROVED RESPIRATOR AS REQUIRED TO PREVENT
OVEREXPOSURE.USE EITHER AN ATMOSPHERE SUPPLYING RESPIRATOR OR AN
AIR PURIFYING RESPIRATOR FO R ORGANIC VAPORS.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS WITHIN SUGGESTED PEL/TLV LIMITATIONS.
Protective Gloves:WEAR CHEMICAL RESISTANT GLOVES
Eye Protection:WEAR SAFETY GLASSES OR GOGGLES
Other Protective Equipment:SAFETY SHOWER, EYE BATH AND WASHING
FACILITIES SHOULD BE AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP/WATER BEFORE
EATING,DRINKING,SMOKING OR USING TOILET FACILITIES.NO SMOKING WHERE
MATERIAL IS USED/STORED.
Supplemental Safety and Health
*NOTE TO DOCTOR:MORE THAN 2.0 ML PER KG IS INGESTED AND VOMITING HAS
NOT OCCURED,EMESIS SHOULD BE INDUCED W/SUPERVISION.KEEP VICTIM HEAD
BELOW HIP TO PREVENT ASPIRATION.IF SYMPTOMS AS LOSS OF GAG REFL
EX,CONVULSIONS/UNCONSCIOUSNESS OCCUR BEFORE EMESIS,GASTRIC LAVAGE
USING A CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.

HCC:F4
Boiling Pt:B.P. Text:323 TO 390F
Vapor Pres:0.1 PSI
Vapor Density:HEAVIER
Spec Gravity:.874
Evaporation Rate & Reference:SLOWER THAN ETHER

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
SODIUM OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:AVOID HEAT, FLAME
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS DURING COMBUSTION.

Waste Disposal Methods:SEAL CONTAINERS,LABEL PROPERLY AND DISPATCH TO
APPROVED WASTE DISPOSAL FACILITY.ASSURE COMPLIANCE WITH ALL
LOCAL,STATE AND FEDERAL REGULATIONS.IF THIS PRODUCT BECOMES A WASTE
MATERIAL,IT WOULD BE IGNI TABLE HAZARDOUS WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.